Patented Energy Saving System for Recovering Wasted Heat in Boiler Rooms

| From

Applying System throughout U.S. Would Lead to Tremendous Savings

ST. JOHN, Ind. - Mar. 12 (SEND2PRESS NEWSWIRE) -- Applied Scientific Research Inc. is introducing a new energy saving system, based on the patents 4,759,195 and 5,878,588. The Wasted Thermal Energy Recovery System is designed to recover heat from boiler rooms, which are found all over the world. It is easy to see that The Wasted Thermal Energy Recovery System saves both money and tremendous energy.

Boiler rooms, which are found in many facilities, are full of wasted heat. In the winter boiler room temperatures are about 110-degrees F (at the ceiling), and in the summer the temperature climbs to 135-degrees F. All of this is wasted heat and wasted energy.

All of the wasted heat escapes from: the boiler shell, hot water heaters, un-insulated steam pipes the stack pipe and other equipment in the boiler room. Most of the heat escapes through the ceiling.

The Wasted Thermal Energy Recovery System recovers the heat from the ceiling, not from around the boiler, with a heat exchanger, (heat absorber), that has cold water running through it. This ceiling heat supplies the three therms/hour needed to raise the inlet water temperature about 30-degrees F, It is channeled into the water inlet, which supplies the boiler.

This saves money and energy. Example: A 350hp boiler at 82 cents per therm would save about $21,000 a year on the cost of natural gas. This system does not use any pumps or holding tanks.

Other technologies preheat intake water such as stack recovery systems. Though these systems can raise the inlet water temperature higher then ours, they are extremely expensive. For example, a 350hp boiler (one which would be found in a factory) would cost $30,000 approximately for the unit and installation. Our unit can be designed to fit any size boiler. Our system cost is $8,200 a unit, and about $2,000 for installation. Our system pays for itself in six months.

This would benefit: schools, hospitals, buildings, factories, and universities. The Wasted Thermal Energy Recovery System is much more economical, therefore is a more practical investment.

In order to insure that this system can be fully beneficial, and accessible we have decided to make it available for licensing. Applied Scientific Research Inc. is a small company, working with energy saving technology, in a world where energy is over used, and wasted. We would like to see this wasted energy be put to use by saving money, energy, and conserving natural gas.

More information: (219) 776-4623.

Applied Scientific Research Inc, P.O. Box 35, St. John, IN 46373-0035 USA.

Text provided by the news source.

News Source:
Like, Share, Save this press release:
  TWEET   SHARE   G+   STUMBLE   LinkedIn   Instapaper   Buffer

The content of the above press release was provided by the “news source” (Applied Scientific Research Inc.) or authorized agency, who is solely responsible for its accuracy. Send2Press® is the originating wire service for this story and content is Copr. © 2007 Applied Scientific Research Inc. with newswire version Copr. © 2007 Send2Press (a service of Neotrope). All trademarks acknowledged.

Rights granted for reproduction by any legitimate news organization. However, if news is cloned/scraped verbatim, then original attribution must be maintained with link back to this page as “original syndication source.” Resale of this content for commercial purposes is prohibited without a license. Reproduction on any site selling a competitive service is also prohibited. Information is believed accurate, as provided by news source or authorized agency, however is not guaranteed, and you assume all risk for use of any information found herein/hereupon. This work is licensed under a Creative Commons Attribution-NonCommercial 3.0 Unported License.
STORY READS for this single page only, as of Oct 28 2016:
[ count retired 8.4.16 ]

or: Search

back to top
REFERENCES: Applied Scientific Research Inc, Thermal Energy Recovery System, Applied Scientific Research Inc, patent, The Wasted Thermal Energy Recovery System, recover heat from boiler rooms, energy saving system, patents 4,759,195 and 5,878,588, , news, press release from Applied Scientific Research Inc., Mar 12, 2007, Patent and Trademark, , , , , Patented Energy Saving System for Recovering Wasted Heat in Boiler Rooms